Skyjacker DS220 Bedienungsanleitung PDF herunterladen

Installation:

1. Park the vehicle on level ground,

set the emergency brake, & block

the front tires / wheels.

2. Raise the driver side of the

vehicle. Remove the front tire /

wheel & OEM shock at the lower

mount.

3. Position the new Skyjacker upper

mount at the rear of the OEM

spring tower. (See Photo # 1)

Align the new upper mount so the

top of the mount is parallel to the

ground & the two holes can be

drilled into the spring tower. Drill

the two holes into the upper

spring tower & mount the bracket in place. Install the new Skyjacker shock into the new upper

shock bracket. Note: If you prefer, you may weld the bracket in place.

4. Install the bottom of the shock using the supplied 1/2" x 5 1/2" bolt. Place a 1/2” washer on the

bolt before putting it through the first shock. Insert the bolt through the outside shock, install a

washer, spacer, & then another washer. Push the bolt through the OEM shock bracket, shock, &

radius arm. Install a washer & nut, then tighten.

5. Repeat the above steps on the passenger side.

6. Once all shocks are installed, check all components for proper clearance. Retorque all hardware

after the first 100 miles & periodically there after.

NOTE: THE STEERING STOPS MAY NEED TO BE ADJUSTED AFTER THE INSTALLATION OF

THIS DUAL SHOCK KIT TO AVOID INTERFERENCE WITH THE SHOCK WHEN YOU TURN

FULL LEFT OR FULL RIGHT.

Seat Belts Save Lives, Please Wear Your Seat Belt.

83-97 Ford Ranger/Bronco II

Front Dual Shock Kit

Installation Instructions

Part # DS220

I-DS220 REV2 3-11

Front

Rear

Part # Description Qty

DS280-LB LEFT DUAL SHK BKT,RANGER 1

DS280-RB RIGHT DUAL SHK BT,RANGER 1

38X1CTBG5 3/8 X 1 CRSE THRD BLT,GRD 5 4

38CTN 3/8-16 COARSE N/I LOCK NUT 4

38SAEW 3/8 SAE WASHER 4

12X512CTBG5 1/2 X 5 1/2 CRS THD BLT,GR5 2

12SAEW 1/2 SAE WASHER 8

12CTN 1/2-13 COARSE N/I LOCK NUT 2

DSS1234 DUAL SHOCK SPACER 1/2 X 3/4 2

I-DS220 INST. SHEET FOR DS220 1

Important Note: This dual shock kit is to be used with the OEM radius arms. If

your vehicle is equipped with aftermarket radius arms, do not install this dual

shock kit.

www.skyjacker.com

Photo # 1

Pg 1

1 2

Inhaltsverzeichnis

Seite 1

Installation:1. Park the vehicle on level ground, set the emergency brake, & block the front tires / wheels. 2. Raise the driver side o

Seite 2 - Jesús murió por ti

Check out our favorite ministries at:www.innministries.orgwww.familychurch.orgwww.kcm.orgJesus Forgives, Rocks Don’tJesus Christ Died For You.John

Kommentare zu diesen Handbüchern

Keine Kommentare

Skyjacker DS220 Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Für das Auto Skyjacker DS220 herunter. Skyjacker DS220 User Manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Für das Auto Skyjacker DS220